140XBP00300 Quantum

在潤滑油壓力的測量中，由于潤滑油壓力信號參與停機聯鎖控制。潤滑油壓力變送器測量所得的信號傳輸給計算機，一方面進行顯示，另一方面此信號還通過程序比較，當壓力低于0.06MPa時，發出缺油停機信號停機。

從潤滑油壓力信號趨勢圖上看到壓力是瞬時直線下降而導致跳機的，檢查變送器后發現變送器的內部模塊損壞。雖然每年都對變送器進行定期的校驗，檢定合格后用于生產。由于變送器經過幾年的運行后，其精度、靈敏度、穩定性等性能指標都會逐漸降低，內部的膜片、集成塊也會損壞發生故障。

存在干擾問題 

在空壓機排氣壓力的測量中，排氣壓力信號的波動較大。校驗變送器后符合精度要求，排除變送器本身的故障；檢查導壓管及接頭也沒有破損、漏氣，信號電纜的連接處接觸良好。但電纜的走向是通過高配室旁邊的電纜橋架引入控制室的。周圍存在著大量的電磁干擾。

Siemens Simatic S5 6AV1242-0AB10 6AV12420AB10

Siemens Simatic S5 OP15-A OP-15-A 6AV3515-1EB01

Siemens Simatic S5 6ES5511-5AA14 6ES5-511-5AA14 

Siemens Simatic S5 6ES5525-3UA11 6ES5-525-3UA11 NEU OVP

Danfoss Frequenzumrichter 12,6kVA VLT 3011 175H7273 RFI

Siemens Simodrive 611 PPU Power Unit 6SN1128-1EA00-0CA0

Mitsubishi AC-Servo Amplifier MR.J2S-70B 0,75kW 

ABB C5 Roboter General GIC-03 E3E032235 3E032235 NEU

ABB C5 Roboter General GIC-03 E3E032235 3E032235 NEU

Siemens Simodrive 611 6SN1145-1AA00-0AA0 10/25kW

Vergr??ern

Siemens Sinumerik System 8M Rack 6FC3381-0EA-Z

SEW Eurodrive Movitrac 1015-403-4-00 2,8kVA / 1,5kW

SEW MOVIDRIVE MDV60A0015-5A3-4-00 1,5kW + MDX + Opt. 

SEW MOVIDRIVE MDV60A0030-5A3-4-00 3,0kW + MDX + Opt. 

Siemens Simatic Motorsteuerung SMP-E362 C8451-A13-A8

Heidenhain Ma?stab LS 481 ML 920mm NEU 37284925 AS0006

Siemens Simoreg Board C98043-A1045-L1-03

Siemens Simoreg Board C98043-A1045-L1-D2

Siemens Sinumerik Kuka ACR-GRT-PHG 6FR2490-0AH12

Bosch Rexroth Servo Modul DM-4K-3301-D 1070077616-111

Bosch Rexroth Modul NV20/1F-D NV 20 1070078431-202

SICK Lichtvorhang 30-FGS FGSE1500-21 1012617 

SICK Lichtvorhang 30-FGS FGSS1500-21 1012616 Sender 

SICK Lichtvorhang 30-FGS FGSE1500-21 1012617 

SICK Lichtvorhang 30-FGS FGSE1200-21 1012613 NEU

SICK Lichtvorhang 30-FGS FGSS1200-21 1012612 NEU

Siemens Servomotor 1FT5072-1AF71-1AA0 Perm Magnet Motor

Siemens Servomotor 1FT5072-1AF71-1AA0 Perm Magnet Motor

Servo Umrichter Kollmorgen Servostar 603 S60300

Siemens Servomotor 1FT6081-8AH72-3SG0 4500 U/min 5,8Nm

Siemens Simatic S5 PG 6ES5501-5AA11 6ES5-501-5AA11

Siemens Netzger?t SVS2 6EV1363-5AK 6EV-1363-5AK 40A

Siemens Simatic S5 Netzteil 6ES5955-3LF12 6ES5955-3LF12

Siemens Simoreg Komfortregler C98043-A1098-L11-06

Siemens Simatic S5 6ES5415-7AA31 6ES5-415-7AA31 V.B NEU

Siemens Simatic S5 Moby 6ES5254-4UA11 6ES5-254-4UA11

FANUC Memory Module Shared Ram Board A16B-1211-0860

FANUC Memory Module Shared Ram Board A16B-1211-0042

Siemens Sinumerik Sirotec 6FX1111-0AP02 D07 NEU OVP

Siemens Sinumerik Sirotec 6FX1122-1AC02 C07 NEU OVP

Siemens Sinumerik Sirotec 6FX1130-6BA00 A00 NEU OVP

Siemens Simatic S5 IP242B 6ES5242-1AA41 6ES5-242-1AA41

Siemens Simatic S5 Moby 6GT2002-0AA00 + 6GT2002-0AB00

FANUC Power Unit A20B-1000-0770-01 Power Supply

Siemens Sinumerik OPI-VGA-BG Karte 6FX1147-1BA01

Siemens Sinumerik Servo Karte 6FX1126-8BB00

Siemens Sinumerik CPU Master Karte 6FX1122-5CD00 NEU

Siemens Simoreg Komfortregler C98043-A1098-L11-04

Siemens Simovert Masterdrives 6SE7014-0TP50-Z +C23+G91

Siemens Simovert Masterdrives 6SE7021-0EP50-Z H0021

Siemens Sinumerik Sirotec 6FX1123-7AB02 Board

Siemens Sinumerik Sirotec 6FX1127-4AD01 Board

Siemens Sinumerik Sirotec 6FX1120-2AB03 Board

Siemens Sinumerik Sirotec 6FX1122-5CD01 Board

Siemens Simatic S5 IP241 6ES5241-1AA11 6ES5-241-1AA11 

Siemens Simatic S5 OP15-B OP-15-B 6AV3515-1MA01

Loctite 1324000 Halbautomatisches Compact Dosierger?t 

SEW MOVIDRIVE MCV-41A-0015-5AE-4-00 1,5kW NEU OVP

Heidenhain Ma?stab LB 301 ML 1200mm NEU 28466802 Geh.

Siemens Simoreg FBG-Steuersatz C98043-A1005-L2-15 table

Siemens Simatic S5 6ES5955-3LF12 6ES5-955-3LF12

Siemens Simoreg AMP Board C98043-A1046-L1-11

Siemens Sitrans F M Magflo MAG 6000 7ME6920-2CA10-1AA0

Beckhoff CP-Link DVI Karte CP9035 CP-9035 + C9900

Siemens Sinumerik Sirotec Kuka Memory 03420 Out 

Siemens Simodrive 611 6SN1123-1AB00-0BA1 2x25A Vers.A

Siemens Simoreg Simodrive 610 6SC6108-0SE01

Siemens Simatic S5 6ES5944-7UA22 6ES5-944-7UA22 CPU944B

Siemens Simodrive 611Regelkarte 6SN1118-0AA11-0AA1

Siemens Simatic S5 WF470 6FM1470-4AA25 Video Display

Siemens Simatic S5 6ES5944-7UA22 6ES5-944-7UA22 CPU944A

Siemens Simatic S5 OP15-A OP-15-A 6AV3515-1EB00

Siemens Sinumerik Sirotec 6FX1191-0AB00 03800

Siemens Simatic S5 OP15-B OP-15-B 6AV3515-1MA01

Siemens Simatic S5 OP15-B 6AV3515-1MA01 6AV3-515-1MA01

Weber WSG100 Operator Panel + Controller WSG 100

Siemens Simoreg Komfortregler C98043-A1098-L11

Siemens Simodrive 611 6SN1146-1AB00-0BA1 U/E-Modul

FANUC Power Supply Module PSMC-30HV A06B-6083-H230 

Siemens Simatic S5 6ES5247-4UA31 6ES5-247-4UA31 

Siemens Simatic S5 CPU921 6ES5921-3WB11 6ES5-921-3WB11

Siemens Simatic S5 CP544 6ES5544-3UA11 V07  OVP

Siemens Simatic S5 6AV1242-0AB10 6AV12420AB10 V08

Siemens Sinumerik Sirotec CPU 6FX1123-3CA00 KUKA NEU

Siemens Sinumerik Sirotec 6FX1123-8CA04 KUKA NEU

Siemens Sinumerik Sirotec Videographik 6FX1151-1BD01

Siemens Simodrive 611 U/E Modul 6SN1145-1AA00-0AA0 V.B

Siemens Simodrive 611 U/E Modul 6SN1145-1AA00-0AA0 V.A

Siemens Sinumerik System 8M Rack 6FC3381-0FA-Z

Siemens Simatic S5 IP2421 6ES5242-1AA32 6ES5-242-1AA32

Siemens Sinamics Control Unit CU320 6SL3040-0MA00-0AA1 

Siemens Simatic S5 6AV1242-0AB10 6AV12420AB10

Siemens Sinumerik Video Karte 6FX1154-8BB01

Siemens Simoreg Board C98043-A1047-L111-05

Siemens Simoreg Board C98043-A1047-L111-04

Siemens Simoreg Board C98043-A1047-L111-06

Siemens Simodrive 611 VSA-Modul 6SN1130-1DA12-0DA0 

Siemens Simovert P Umrichter 6SE2008-2AA00 7,5kW

Siemens Phoenix Interbus IBS S7-400 ETH DSC I-T 2731102

Siemens Simodrive 610 Leistungsteil 6SC6170-0FC01 70A

Siemens Simodrive 610 Leistungsteil 6SC6130-0FE01 30/60

Siemens Sinamics Basic Line Module 6SL3130-1TE22-0AA0

INDRAMAT AC-Servo Controller TDM-3.2-020-300-W0

Siemens Simodrive Simoreg 610 FBG 6SC6108-0SE02 

Siemens Simatic S5 CPU944 6ES5944-7UA22 6ES5-944-7UA22

Siemens Simodrive 610 Leistungsteil 6SC6170-0FC50 70A

Siemens Sinumerik Sirotec 6FX1122-1AC02 A00 NEU OVP

Siemens Simatic S5 6ES5944-7UA22 6ES5-944-7UA22 CPU944B

Siemens Simodrive 611Regelkarte 6SN1118-0AA11-0AA1

Siemens Simatic S5 WF625 6FM1610-2CB00 Version C7

Siemens Sinumerik CPU 6FX1132-8BB01 Vers. D 

Siemens Masterdrives 6SE7014-0TP50-Z G91 K80+C43

Siemens Simodrive 610 Leistungsteil 20A 6SC6120-0FE01

Siemens Simodrive Simovert Power Supply 6RB2000-0GB01

Siemens Sinumerik Sirotec 6FX1125-0CB01 KUKA NEU

Siemens Simatic S5 IP241 6ES5241-1AA11 6ES5-241-1AA11 

Siemens Simodrive 610 Leistungsteil 6SC6170-0FC01 70A

Siemens Sinumerik OP 31 6FC5203-0AB10-0AA0 + Converter

Siemens Simoreg Hauptspindelregler C98043-A1086-L11-08